Top » Catalog » PressSavers » 0

$0.00

Care of Alcohol Dampener Rolls
[0]

Care of Alcohol Dampener Rolls
Proper roller maintenance is critical to keeping your alcohol dampener in good condition and operating at its optimum.

Metal rollers must be kept clean, smooth and free of oxidation, and soft rolls must stay soft and sensitized to remain hydrophobic and ink free.

Metal rollers can be cleaned with most good quality plates cleaners, then wiped clean with water and coated with a 50/50 solution of gum and water.

Rubber rollers require special care since they have open surface pores that can accumulate/collect contaminates from the printing process. Ink pigments, paper sizing, and traces of some alcohol substutites accumulate in the roller surface causing the roller to loose its' hydrophobic affinity to where it carries less and less water and eventually picks up ink.

When this happens you must deglaze and recondition the soft rollers to re-develope and sensitize it's surface to reject ink and attract water.

First you must remove all contaminates with a good cleaning. A product called 'Mati-clean' works well as the first step in removing roller contaminates. It cuts ink pigment and paper sizing well. A 50/50 mix of a good water misible roller wash also works well as the step #1 wash to remove surface contamination.

Once you have performed a complete step #1 wash, step #2 is to rinse and lightly scrubb the rollers with a liberal application of isopropl alcohol to remove any hint of a petroleum film/residue from the rolls.

Then step #3 is an application of a 50/50 mix of gum and water will coat the roller to where it will accept fountain solution without rejection.

When not using your press, always coat your 'clean' fountain rollers with an application of 50/50 gum and water to seal the surface until next use.

A quick test to tell if your rubber rollers are becoming contaminated is to wipe them briskly with a cotton pad saturated with isopropl alcohol. If you wipe off a purple stain its an indication that your rollers are absorbing blue paste toner and other dyes used in ink.

If you find that you are increasing your water setting, chances are your rollers need to be cleaned and re-conditioned.

Note: If this cleaning procedure does not bring your soft rollers back into a usable state, check durometer to determine if rubber has hardened beyond specifiactions.

In an emergency situation, you can hand scrub soft rolls with a fast dry deglazer to remove a deep glaze condition, but always follow up with alcohol and then 50/50 gum solution before use.

If durometer it too hard (beyond specs) replace all soft rolls as a set.

Reviews
Quick Find
 
Use keywords to find the product you are looking for.
Advanced Search
Manufacturers
2 x Kwik Kolor RYB-32 Ink Fountain
1 x 24 Pack Kompac ll Cleaning Seals
1 x M1819-1-KM
1 x 33R40 Water Form Roller "H" Water System
1 x #92145, 11 5/8" Metering Roller W/Bearings
1 x 91306, 13" Long Travel Oscillator
1 x AF15G-KM
2 x 94810-Syntac (92K16) GT52 form roller
1 x #090973, 13 1/4" Form Roller W/Bearings
1 x AF17-KM
1 x 91301, 10 5/8" Long Travel Oscillator
1 x #92810 Gear/Clutch Assembly
1 x #92880 Gear/Clutch Assembly
2 x #91410 Form Roll W/Bearings
1 x #092765 "O"
1 x RYB2728-KM
3 x 91546 Nylon Set Screw M4x6
2 x 3302 & 3985 Service Manuals
1 x V-91802 Screw for backing plate tab
1 x #94770 Form Roll W/Bearings
2 x GESTETNER SUCKER TUBES
1 x 92780
2 x 98750 nozzle bracket assy
1 x RYB334
1 x Li Shiang Wang FEDEX Shipping Charge
2 x AF15-KM
1 x #95510 Metering Roller W/Bearings
1 x M125
2 x 16 Gal Refrigerated LC 4-6/Color
1 x 92778 Blue Suction Syringe
2 x V-92612 metering guage
2 x #90860 Gear Assembly
2 x 92290 Kompac II complete backing plate kit
1 x 91545 Compression Spring
1 x 91490 Kolormate Oscillator
2 x GST13
1 x RYB2728
1 x #92040, 18 3/8" Form Roll W/Bearings
1 x 71-109-05 Astro Envelope Feeder Sheet Separator
1 x #92420, 11 & 1/8" Metering Roll W/Bearings
1 x 91760 M4 X 10MM CAP SCREW
2 x Ryobi / Itek New Style Sucker Tubes
1 x #092756, 1/2" I.D. Vinyl Tubing
1 x 90910 LH BRKT ASSY. ABD 9800
1 x 91412 Metering Roller Eccentric
1 x AF17G
1 x 91315 Kolormate Oscillator
2 x #91800 Gear/Clutch Assembly
1 x #92415 Thrust Washer
1 x RYB522R-KM
1 x #92410, 11" Form Roll W/Bearings
1 x 91423 Oscillator Block LH
2 x 92370 One Set Kompac II Seals
1 x #92520, 11 & 1/2" Metering Roller W/Bearings
1 x #92720, 23 & 1/4\" Form Roller
3 x 95717 Kolormate Oscillator
2 x 94998, 13 1/4" Kolormate Oscillator
1 x #92830 Gear/Clutch Assembly
1 x 91309, 18 3/8" Kolormate Oscillator
1 x GTO52-K 9-Roll soft ink roller kit for GTO 52
1 x A92777 Low Profile Bottle & Cap Assembly
2 x HMD-248/252 Recirculator Module
1 x #95420 Metering Roller W/Bearings
1 x M125-KM
1 x #94240, 13 & 1/4" Metering Roller W/Bearings
2 x 91756 8mmx1.25.25 cap screw
1 x #092771 Calibrated Fountain Bottle
1 x 91514 Spring
1 x #92550, 12 11/32" Form Roll W/Bearings
1 x 91571 Oscillating Mounting Block
1 x M125IPC-KM
1 x 91414 tie plate GT-46
2 x #92860 Gear/Clutch Assembly
1 x #92890 Gear/Clutch Assembly
1 x 91708 6MM X 30MM SHOULDER SCREW
1 x RYB-5102 Recirculator Module
1 x 92180 Ten Set Pack Kompac II Seals
2 x #092750 Adaptor Base Assembly
2 x #92910 Gear/Clutch Assembly
1 x #98186 Metering Roller W/Bearings
1 x M1316IPC
1 x 91895 BUTTON HEAD SCREW
1 x #92850 Gear/Clutch Assembly
1 x 32R-K Soft Ink Roller Kit for Ryobi 3302/Itek 3985
1 x 93346 Kolormate Oscillator
1 x V-93857 bushing
1 x #92693 Form Roll Without Bearings
1 x 95930 COVER ASSEMBLY
1 x 93818 ECC. SHAFT BUSHING
1 x 96460 Kolormate 25 Oscillator Kit
2 x #92400 11" Metering Roller W/Bearings
1 x #91900, 13 1/4" Form Roll W/Bearings
1 x 96087 RYB334
1 x AF17G-KM
1 x RYB32MCD-KM
1 x #92491 Wave Washer
2 x #90840 AD 500/506 FORM ROLLER W/ BEARINGS
1 x 8 Gal Refrigerated LC 1/Color
1 x GST11-KM
2 x #90959 Gear/Clutch Assembly
1 x 33R51P Water Metering Roller for "H" Water System
2 x 91547 Hex Jam Nut
1 x 91313, 18 3/8" Long Travel Oscillator
1 x 91910 COLLAR
1 x #92694 Metering Roller Without Bearings
1 x #92540, 12 11/32" Metering Roller W/Bearings
1 x RYB522-KM
1 x #92450, 10 & 5/8" Form Roll W/Bearings
2 x #91420 Metering Roller W/Bearings
1 x 93805 BOLT RETAINER ASSY.
1 x #90973, 13 1/4" Metering Roller W/Bearings
1 x RYB5102-KM
1 x GST12
1 x #91966 Spacer Washer
1 x 91303, 11 1/2" Kolormate Oscillator
1 x 92260 Old Style seal set
1 x 91572 osc. mounting block
2 x #92580 Metering Roller W/Bearings
1 x DMCP Recirculator Module
1 x 92185 Five Set Pack Kompac II Seals
1 x 91470 Kolormate Oscillator
1 x #92870 Gear/Clutch Assembly
1 x AF15
1 x 90850 1 Set Pack Kompac III Seals
2 x M1316
1 x RYB3200W-KM
2 x 96510 Kolormate 10 Oscillator Kit
1 x 91304, 12 11/32" Kolormate Oscillator
2 x RYB33-KM
1 x #94760, 13" Form Roll W/Bearings
1 x #91405 Gear Assembly
1 x 98035 Spring Rod
1 x M2629
1 x #92920 Gear/Clutch Assembly
1 x #92430, 11 & 1/8" Form Roller W/Bearings
1 x M125IPC
2 x #91990 Gear/Clutch Assembly
1 x M125ML
1 x LOR-960-A-K RYOBI 2800/ITEK 960 5 PIECE INK ROLLER KIT OLD STYL
1 x GST11
1 x AF17
1 x RY-332 Kwik Kolor PKG-50 Ink Fountain Liners
2 x #98545 Metering Roller W/Bearings
2 x 2.0x4.0 Spot Blanket
2 x 98260-10 Sets Kompac IV Seals
2 x 16 Gal Refrigerated LC 1-3/Color
2 x #92710, 23 & 1/4" Metering Roller W/Bearings
2 x #90889, 13 1/4" Metering Roller W/Bearings
1 x GST13-KM
1 x RU 79 Astro Envelope Feeder Sucker Foot - 1 dozen
1 x #95522 Gear Assembly
1 x #94051 LH 2728 Mounting Bracket
1 x #94250, 13 1/4" Form Roll W/Bearings
1 x V-93869 nylon bushing
1 x 12MM Clutch/Bearing Press Kit
1 x V-92491 wave washer
1 x 91408 Tie Rod for GT-46
2 x Press Vacuum Test Gauge
2 x Re-Surfacing Kompac Form Roll
1 x 91649 Shoulder Screw
1 x 8 Gal Non Refrigerated 1-2 Color
1 x 91407 Backing Plate Stand-off
1 x Cleaning Your Kompac On-The-Fly
1 x #92530, 11 1/2" Form Roll W/Bearings
1 x 10.75x19&3/8 Slim Blanket
1 x 94054 bushing
1 x BigFoot Sucker Tubes Hamada E47;C248;C252;SU47;611;612;662
1 x #98732 Metering Roller W/Bearings
1 x #92470, 13" Form Roller W/Bearings
1 x 91814 3/4" Set Screw
1 x Wet-Sanding Kompac Metering Rolls
1 x #92604 Nozzle
1 x 91424 Oscillator Block RH
1 x AB 5060 Mounting Bracket Kit
1 x 11.75x19&3/8 Slim Blanket
1 x #092760 Dispenser Valve Assembly
1 x Care of Alcohol Dampener Rolls
$131.00
Manufacturer Info
PressSavers
Other products
Share Product
Share via E-Mail Share on Facebook Share on Twitter Share on Google Buzz Share on Digg